BMW 330i Starter Relay Fire Risk Recall 2025 — Your Lemon Law Rights

Quick Answer (TL;DR)

BMW of North America, LLC is recalling 200K vehicles — including the 2019-2022 BMW 330i — because starter relay fire risk (NHTSA campaign 25V636000, reported September 23, 2025). The remedy: . If the defect persists after the fix, or your dealer can't complete the repair within 30 days, you may qualify for a buyback, replacement, or cash compensation under your state's lemon law.

« See all active vehicle recalls tracked by Easy Lemon

Recall at a Glance

What Is the Defect?

BMW of North America, LLC is recalling certain 2019-2022 BMW 330i vehicles. Certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overhea...

The Safety Consequence

NHTSA classifies this as a safety-of-life issue. The remedy must be completed by an authorized BMW dealer; owners should not delay scheduling the fix.

The Manufacturer's Remedy

BMW of North America, LLC will provide the following remedy free of charge: . Owners may contact BMW customer service at 1-800-525-7417 — referencing NHTSA campaign 25V636000.

Owner Timeline — What to Expect (Weeks 1-4)

For most 330i owners, the recall repair follows a predictable path. Here's the typical 30-day window — and where lemon-law rights start to apply if it goes off track:

Does This Qualify for Lemon Law?

A recall by itself does not automatically qualify a vehicle as a lemon. What matters is whether the defect is fixed after reasonable repair attempts. Most state lemon laws require:

• Substantial impairment to safety, value, or use of the vehicle (the starter relay fire risk clearly qualifies)
• A reasonable number of repair attempts (typically 3-4 for the same issue, or 1-2 for safety defects)
• OR 30+ cumulative days out of service for warranty repairs
• The defect persists despite the manufacturer's attempt to fix

Recall 25V636000 helps a lemon-law claim two ways: (1) the recall itself is documented evidence the defect exists, and (2) if the manufacturer's remedy doesn't permanently fix the starter relay fire risk — or introduces a new problem — that failed remedy is exactly what lemon law was designed to address. The federal Magnuson-Moss Warranty Act adds an additional layer of protection that typically requires the manufacturer to pay your attorney fees.

Your Lemon Law Rights by State

Easy Lemon represents 330i owners nationwide. Lemon-law statutes vary by state — here are key jurisdictions where we have deep state-court experience:

Free VIN Lookup — Is Your 330i Affected?

What to Do Right Now

1. Check your VIN at NHTSA.gov/recalls to confirm your 2019-2022 BMW 330i is included in campaign 25V636000.
2. Schedule the recall repair at an authorized BMW dealer (1-800-525-7417). The repair is free of charge.
3. Save every repair order. Get a paper or digital copy showing date, mileage, technician notes, and campaign number 25V636000.
4. Document any incidents. If the defect returns after the recall fix, log the date, time, mileage, road conditions — and photos or video if safe. This evidence is critical for a lemon-law claim.
5. Contact a lemon law attorney if the defect returns, if your dealer can't complete the fix within 30 days, or if your VIN is on a do-not-drive list. Get a free case review here.

Past BMW Lemon-Law Settlements

Easy Lemon has recovered millions for BMW owners nationwide. Three representative outcomes:

Easy Lemon — No Cost Case Review

Easy Lemon represents vehicle owners nationwide, with deep state-court experience in Florida, Texas, Georgia, Arizona, New York, and New Jersey. No upfront fees. When we win, BMW of North America, LLC typically pays our attorney fees under the federal Magnuson-Moss Warranty Act.

Call 1-866-LEMON-99 or submit your case online — VIN check is free.

Frequently Asked Questions

Is the 2025 BMW 330i starter relay fire risk recall covered by lemon law?

Yes, if the defect substantially impairs the safety, value, or use of your 2019-2022 BMW 330i and cannot be repaired after reasonable attempts. NHTSA campaign 25V636000 itself is documented evidence the starter relay fire risk exists — strengthening any lemon-law claim under state law and federal Magnuson-Moss.

What if my BMW dealer can't perform the recall repair?

If BMW of North America, LLC or its dealer network cannot complete the for recall 25V636000 within roughly 30 cumulative days, that delay can independently qualify the vehicle under state lemon law as an inability-to-repair — even if you never had a failed repair attempt.

Do I need to complete the recall repair before filing a lemon-law claim?

In most cases, yes. Courts and arbitrators expect BMW of North America, LLC to be given an opportunity to cure the defect. Recommended path: complete the dealer's recall repair first, document each visit, and file a lemon-law claim only if the defect persists or the dealer can't perform the fix within 30 days.

How much can I recover under BMW lemon law for the 25V636000 recall?

Three outcomes are common for owners of the affected 2019-2022 BMW 330i: a manufacturer buyback (full purchase price minus a mileage-use deduction), a comparable replacement vehicle, or cash compensation if you keep the vehicle. Federal Magnuson-Moss claims can also recover attorney fees — typically paid by BMW of North America, LLC, not by you.

How do I check if my 330i VIN is affected by recall 25V636000?

Enter your 17-character VIN at nhtsa.gov/recalls. If your VIN is included in NHTSA campaign 25V636000, you'll see the open recall listed. You can also call BMW customer service at 1-800-525-7417 with your VIN, or use the free VIN check on the Easy Lemon contact page to learn about your lemon-law rights.

How long do I have to file a lemon-law claim for the 330i recall?

Statute of limitations varies by state: Florida and Texas typically allow 4 years from the manufacturer's last repair attempt, Georgia 1-2 years, Arizona 4 years, New York 4 years, and New Jersey 6 years. Federal Magnuson-Moss claims may extend the window. Document every repair visit for the 25V636000 fix and contact a lemon-law attorney early to preserve your rights.

What is the remedy for the BMW 330i recall 25V636000?

BMW of North America, LLC's remedy is: . The fix is provided free of charge under federal recall law. If the remedy fails to fix the starter relay fire risk, that failed remedy strengthens your lemon-law case — keep the dealer's repair order and any post-repair incident logs.

Does the starter relay fire risk count as a safety defect?

Yes. NHTSA classifies the starter relay fire risk as a safety issue: . Safety defects typically qualify for lemon-law relief faster than non-safety issues — most state statutes require fewer repair attempts (often just 2) for documented safety defects.

Sources & references:

• NHTSA Campaign 25V636000 — Official recall record
• BMW Customer Service — 1-800-525-7417
• BBB AUTO LINE — Manufacturer arbitration program
• Consumer Reports — Auto recalls & defects